The three sands side by side
| M-Sand | P-Sand | Crusher dust | |
|---|---|---|---|
| Also called | Manufactured sand, concrete sand, எம் சாண்ட் | Plastering sand, பி சாண்ட் | Quarry dust, stone dust, கிரஷர் டஸ்ட் |
| Size | 0–4.75 mm | 0–2.36 mm | 0–4.75 mm |
| Washed | Yes | Yes | No |
| Grading | IS 383:2016 Zone II | IS 1542 plaster sand (IS 383 Zone III/IV) | Not controlled |
| Fineness modulus | 2.6–2.9 | About 1.8–2.4 | Not controlled |
| Use it for | RCC, ready-mix, precast, masonry mortar | Wall and ceiling plaster, pointing, fine mortar, tile bedding | Paver bedding, pipe bedding, trench backfill, plinth filling, block making |
| Never use it for | Smooth plaster finishes | Structural concrete | Concrete or plaster |
| MT per unit (100 cft) | ≈ 4.75 | ≈ 4.6 | ≈ 4.8 |
| Ex-works rate | ₹525 per MT | ₹680 per MT | ₹450 per MT |
P-Sand full form: plastering sand. It is the finer, washed cut of the same crushed granite, made so a 12 mm coat spreads and finishes without pits.
Which sand for which job
| Job | Use | Why |
|---|---|---|
| RCC slab, beam, column, footing | M-Sand | Zone II grading suits the mix design |
| PCC bed under footings and floors | M-Sand, or as your engineer specifies | Same sand as the RCC keeps the order simple |
| Brick and block mortar | M-Sand or P-Sand | P-Sand gives thinner, neater joints |
| Internal wall plaster, 12 mm | P-Sand | Finer grading finishes smoothly |
| External plaster, 18–20 mm | P-Sand | Same reason; laid in two coats |
| Ceiling plaster, about 6 mm | P-Sand | A thin coat needs fine sand |
| Tile bedding and screed | P-Sand | Fine, even bed |
| Paver bedding, 25–40 mm | Crusher dust | Compacts tight and costs less |
| Pipe bedding, trench backfill | Crusher dust | No large stones to press on the pipe |
| Plinth and floor filling | Crusher dust | Compacts to about 2.0–2.15 t/m³ |
| Hollow and solid block making | Crusher dust with 6mm chips | Dust fills the voids between chips |
From our team
Notes, photos and examples added by the M&B Chetty team, with the author and the date.
Three mistakes that cost more than the sand
- Crusher dust in a slab. The uncontrolled fines soak up water and cement, the mix bleeds and cube results drop. The saving per tonne is small next to the cost of a weak slab.
- Zone II M-Sand in plaster. The coat stays rough and the mason adds cement and water to make it finish. Use P-Sand.
- Unwashed sand sold as washed. "Double washed" is a sales phrase, not a test result. Do the jar test and ask for the lot's 75-micron figure.
Which is costly, M-Sand or P-Sand?
- P-Sand, ex-works: ₹680 per MT
- M-Sand, ex-works: ₹525 per MT
- Crusher dust, ex-works: ₹450 per MT
P-Sand is screened finer, so it usually sits a little above M-Sand per tonne. The gap between dust and the washed sands is the cost of washing and grading; buy dust for dust jobs, not as cheap sand.
How much of each you will need
- M-Sand for concrete: about 0.7 MT per m³ of M20 concrete; a 1,000 sq ft, 5-inch slab needs about 8 MT.
- P-Sand for plaster: about 0.2 MT per 100 sq ft of 12 mm plaster, so one tonne covers roughly 500 sq ft.
- Crusher dust for paver bedding: a 40 mm bed under 1,000 sq ft of pavers is about 3.7 m³, roughly 6.3 MT.
- Whole house: about 38 MT of M-Sand and 9 MT of P-Sand per 1,000 sq ft of built-up area.
All four are typical estimates; your engineer's quantities govern. Add 5–10% for wastage when you order.